Flugunfall 11 JUL 1975 einer de Havilland DH-114 Prinair Heron 2 N570PR - San Juan-Isla Verde International Airport (SJU)
ASN logo
 

Status:Accident investigation report completed and information captured
Datum:Freitag 11 Juli 1975
Zeit:04:31
Flugzeugtyp:Silhouette image of generic HERN model; specific model in this crash may look slightly different
de Havilland DH-114 Prinair Heron 2
Fluggesellschaft:Prinair
Kennzeichen: N570PR
Werknummer: 14074
Baujahr: 1954
Betriebsstunden:14859
Triebwerk: 4 Continental IO-520E
Besatzung:Todesopfer: 0 / Insassen: 2
Fluggäste:Todesopfer: 0 / Insassen: 9
Gesamt:Todesopfer: 0 / Insassen: 11
Sachschaden: schwer beschädigt
Konsequenzen: Repaired
Unfallort:San Juan-Isla Verde International Airport (SJU) (   Puerto Rico)
Flugphase: Start (TOF)
Betriebsart:Inländischer planmäßiger Passagierflug
Flug von:San Juan-Isla Verde International Airport (SJU/TJSJ),
Flug nach:Mayaguez-Eugenio M. de Hostos Airport (MAZ/TJMZ),
Flugnummer: 303
Unfallbericht:
Prinair Flight-303, a de Havilland DH-114, was a scheduled air taxi flight from San Juan to Mayaguez, Puerto Rico. There were nine passengers and two crewmembers aboard when the airplane was taxied to the runway at San Juan International Airport for takeoff.
After the aircraft was taxied out, the flightcrew completed the routine engine runup and checklist. They noted roughness when the Nos. 2 and 3 engines were checked; both engines were rechecked, and the takeoff clearance was requested and received.
Takeoff power was applied slowly and by the time full throttle power was set, the airplane had accelerated to between 30 and 40 knots. At this time, the flightcrew heard a loud explosive sound, and the airplane veered to the right. Power was reduced immediately, but directional control was difficult to maintain. The captain, however, was able to keep the airplane on the runway.
The first officer notified San Juan Tower that the takeoff was being aborted; the tower was also advised that an emergency existed and equipment was requested. The airplane was brought to a complete stop and the flightcrew initiated the emergency evacuation of the passengers.
Although all emergency shutdown procedures were completed for the four engines, including the closing of all four mixture controls, and fuel shutoff valves and the turning of magneto switches to the "off" position, the Nos. 1 and 2 engines continued to run. The feathering controls were partially jammed, but after several attempts the No. 1 engine propeller was feathered and stopped. Attempts to shut down No. 2 engine in this manner were unsuccessful, and attempts to change the fuel system cross-feed configuration to terminate the fuel supply also were unsuccessful. The No. 2 engine continued to run for about 10 minutes after the takeoff was discontinued.
Because of concern that an engine fire might develop, the four fire extinguishing systems were discharged, after which the No. 2 engine stopped. The captain then also evacuated the airplane.

Probable Cause:

Probable Cause: "The National Transportation Safety Board determines that the probable cause of the accident was the separation of the No. 1 propeller blade of the No. 2 propeller assembly. The blade separated as a result of vibratory stresses which induced fatigue cracks not readily detectable during routine preflight inspections.
Contributing to the accident were inadequate overhaul inspection procedures at a certificated repair station and inadequate dissemination and enforcement of recommended maintenance practices by the Federal Aviation Administration."

Accident investigation:
cover
Investigating agency: NTSB
Status: Investigation completed
Duration: 278 days (9 months)
Accident number: NTSB-AAR-76-13
Download report: Final report

Informationsquelle:
» NTSB


Sicherheitsempfehlungen

NTSB issued 2 Safety Recommendations

Show all...

Fotos

Add your photo of this accident or aircraft

Map
This map shows the airport of departure and the intended destination of the flight. The line between the airports does not display the exact flight path.
Distance from San Juan-Isla Verde International Airport to Mayaguez-Eugenio M. de Hostos Airport as the crow flies is 122 km (76 miles).

This information is not presented as the Flight Safety Foundation or the Aviation Safety Network’s opinion as to the cause of the accident. It is preliminary and is based on the facts as they are known at this time.
languages: languages

Share

The Aviation Safety Network is an exclusive service provided by:
Quick Links:

CONNECT WITH US: FSF Facebook FSF Twitter FSF Youtube FSF LinkedIn FSF Instagram

©2023 Flight Safety Foundation

701 N. Fairfax St., Ste. 250
Alexandria, Virginia 22314
www.FlightSafety.org