ASN Aircraft accident Canadair CL-600-2B19 Regional Jet CRJ-200LR N77181 Lake Michigan, MI
ASN logo
 

Status:Accident investigation report completed and information captured
Date:Saturday 7 April 2007
Time:21:23
Type:Silhouette image of generic CRJ2 model; specific model in this crash may look slightly different
Canadair CL-600-2B19 Regional Jet CRJ-200LR
Operating for:United Express
Leased from:Mesa Airlines
Registration: N77181
MSN: 7181
First flight: 1997
Total airframe hrs:24805
Engines: 2 General Electric CF34-3B1
Crew:Fatalities: 0 / Occupants: 3
Passengers:Fatalities: 0 / Occupants: 1
Total:Fatalities: 0 / Occupants: 4
Aircraft damage: Substantial
Aircraft fate: Repaired
Location:Lake Michigan, MI (   United States of America)
Phase: En route (ENR)
Nature:Domestic Scheduled Passenger
Departure airport:Lansing-Capital City Airport, MI (LAN/KLAN), United States of America
Destination airport:Chicago-O'Hare International Airport, IL (ORD/KORD), United States of America
Flightnumber:7264
Narrative:
A Canadair CRJ-200LR, N77181, operated by Mesa Airlines as flight 7264, was substantially damaged when the thrust reverser translating cowling separated from the left engine during cruise flight and struck the horizontal and vertical stabilizers. The airplane was near the eastern shore of Lake Michigan, about 35 miles west-northwest of Grand Rapids, Michigan, when the accident occurred.
The flight crew received a left thrust reverser unlock indication while holding for takeoff. The captain cycled the reverser, and had decided to return to the gate when the messages cleared. With the issue apparently resolved, he elected to takeoff. The captain reported experiencing a small vibration on climb out and, a short time later, he heard a "loud bang" and the "aircraft pitched and yawed/rolled to [the] left." The autopilot disengaged and the left thrust lever moved to idle during the event. The first officer ran the checklist to stow the reverser. The captain decided to continue to the intended destination because the thrust reverser messages had cleared and the vibrations had stopped. The flight subsequently landed uneventfully. The flight data recorder (FDR) indicated that the left engine vibration levels were elevated during the accident flight. Approximately 3 minutes into the flight, the left engine thrust reverser unlocked parameter changed to "On" for about 1 second. About 11 minutes and 20 seconds after takeoff, the left engine vibration level increased momentarily, and both the left and right engine speeds and fuel flows began to decrease. As the decrease in fuel flows was occurring, the airplane rolled right, left, and right again over about a 4-second period. The decrease in engine parameters lasted over 3 minutes before returning to normal. The left engine thrust reverser unlock parameter indicated "On" for about 4 seconds during that time. The left engine vibration levels decreased after the event, below the levels previously recorded during the flight, and approximately to the level of the right engine vibration. The vibration and engine speed variations suggested separation of the left engine translating cowling at that point. The left engine thrust reverser deploy parameter remained in the "Off" state for the entire flight. Additionally, the FDR data revealed that the left engine vibration levels were elevated and left engine thrust reverser did not deploy on the two previous flights. The post accident inspection revealed that the left engine translating cowl had separated from the engine assembly and damaged the empennage. Damage to the thrust reverser components was consistent with prior operation with the reverser out of alignment and jamming of the translating structure.

Probable Cause:

In-flight separation of the left engine thrust reverser translating cowling due to intermittent binding and jamming of the reverser on the accident flight and on previous flights. Contributing factors were the inadequate maintenance action by the operator due to their failure to properly resolve the prior reverser malfunctions, the failure of the pilots of previous flights in not referring earlier reverser deployment failures for maintenance action, and incomplete company/manufacturer's procedures because they did not address anomalous reverser indications during ground operations.

Classification:

Loss/opening of engine cowling
Forced landing on runway

Sources:
» NTSB


Photos

Add your photo of this accident or aircraft

Map
This map shows the airport of departure and the intended destination of the flight. The line between the airports does not display the exact flight path.
Distance from Lansing-Capital City Airport, MI to Chicago-O'Hare International Airport, IL as the crow flies is 285 km (178 miles).

This information is not presented as the Flight Safety Foundation or the Aviation Safety Network’s opinion as to the cause of the accident. It is preliminary and is based on the facts as they are known at this time.
languages: languages

Share

The Aviation Safety Network is an exclusive service provided by:
Quick Links:

CONNECT WITH US: FSF on social media FSF Facebook FSF Twitter FSF Youtube FSF LinkedIn FSF Instagram

©2024 Flight Safety Foundation

1920 Ballenger Av, 4th Fl.
Alexandria, Virginia 22314
www.FlightSafety.org