ASN Wikibase Occurrence # 17517
This information is added by users of ASN. Neither ASN nor the Flight Safety Foundation are responsible for the completeness or correctness of this information.
If you feel this information is incomplete or incorrect, you can
submit corrected information.
Date: | Tuesday 15 April 2008 |
Time: | 09:23 |
Type: | Eurocopter AS 350B2 |
Owner/operator: | Era Helicopters |
Registration: | N213EH |
MSN: | 3158 |
Year of manufacture: | 1998 |
Total airframe hrs: | 4983 hours |
Fatalities: | Fatalities: 4 / Occupants: 5 |
Aircraft damage: | Substantial |
Category: | Accident |
Location: | 1 mile off Glenn Highway, Sheep Mountain, 34 miles E of Chickaloon, AK -
United States of America
|
Phase: | En route |
Nature: | Passenger - Non-Scheduled/charter/Air Taxi |
Departure airport: | Anchorage, AK |
Destination airport: | Chickaloon, AK |
Investigating agency: | NTSB |
Confidence Rating: | Accident investigation report completed and information captured |
Narrative:**This report was modified on July 7, 2015. Please see the public docket for this accident to view the original report.**
The commercial pilot was on a Part 135 passenger flight transporting telecommunication technicians to remote sites. A technician was left at one site, and when the helicopter did not return, he contacted his employer. His employer contacted the helicopter operator. Unable to make contact with the helicopter, the operator contacted the FAA, and reported the helicopter overdue. A search for the helicopter was initiated based on a position report from the helicopter's onboard commercial satellite tracking system. A snowstorm in the search area precluded the use of aircraft in the search, and ground searchers were unsuccessful.
A State Trooper helicopter found the crash site the next morning when the weather improved. The pilot and three passengers were found dead; the fourth passenger, the minor stepson of one of the technicians, had head injuries and hypothermia. According to the operator and survivor, after transporting the first technician, the helicopter landed at a rest area near the highway and picked up another technician and his stepson prior to going to the next site. The stepson was in the left front seat, and the three technicians were in the rear seats. The destination site was about 2.5 miles from the rest area across a ravine. A motorist on the highway saw the helicopter depart from the rest area, and then make a steep descent into a ravine. He said he thought the descent was unusual, but he did not see any impact, and thought the helicopter was working in the ravine. He said the visibility was about 2 miles, and it was snowing lightly.
The helicopter impacted terrain approximately in a level attitude in a near vertical descent, about three-quarters of a mile from the rest area. The terrain at the accident site was rough and uneven, covered with trees, high brush, and snow. The accident flight lasted less than 2 minutes. The surviving front seat passenger recalled the liftoff and departure, then said he felt like he was falling, and that the pilot told everyone to "hold on we're going to crash."
The main rotor blades remained attached to the rotor head; two of the blades were resting on the ground, and the third blade was suspended over the ravine. The uncut brush surrounding the two blades resting on the ground and the downward chordwise bend of the suspended blade were consistent with low rotor rpm at final impact.
Examination of the helicopter's engine and drive train revealed damage signatures indicative of an overtorque event. These signatures included a 7 millimeter misalignment of the engine's module 5 drive nut and torsional damage (twisting) of the engine-to-transmission driveshaft, which shortened the driveshaft, allowing the splines at the aft end of the shaft to disengage, disconnecting the engine from the main transmission. The module 5 drive nut misalignment was consistent with the engine free turbine producing power at the time of the drive nut overtorque. The direction of rotational smearing damage observed on a portion of the splines was indicative of the engine continuing to provide power for a short time after the driveshaft twisted and shortened. The directionality of the driveshaft twisting was consistent with an opposing torque load forward (on the transmission side) of the driveshaft, which could have resulted from a main transmission seizure or a main rotor impact event. Disassembly and examination of the main transmission revealed no evidence of a seizure. Therefore, the overtorque likely resulted from one or more main rotor blade strikes occurring while the engine was powering the main rotor system. Further, the overtorque damage likely occurred before the helicopter's final impact in the ravine because the low rotor rpm signatures observed at the accident site indicated that the engine was not powering the main rotor system and that the rotational energy in the system had been significantly dissipated before that impact.
The helicopter's mai
Probable Cause: An in-flight overtorque of the engine-to-transmission driveshaft resulting in disconnection of the main transmission from the engine. The overtorque likely occurred due to an in-flight main rotor blade contact with snow-covered terrain, precluding significant main rotor blade damage and ground scarring. Contributing to the severity of the surviving occupant's injuries was the helicopter operator's failure to properly monitor their satellite flight-following system and to immediately institute a search once the system reported that the helicopter was overdue.
Accident investigation:
|
| |
Investigating agency: | NTSB |
Report number: | A08F0202 |
Status: | Investigation completed |
Duration: | 1 year and 10 months |
Download report: | Final report |
|
Sources:
NTSB
FAA register: 2. FAA:
http://registry.faa.gov/aircraftinquiry/NNum_Results.aspx?omni=Home-N-Number&nNumberTxt=213EH Location
Images:
photo: NTSB
photo: NTSB
Revision history:
Date/time | Contributor | Updates |
22-Apr-2008 10:37 |
Fusko |
Added |
05-Mar-2010 10:38 |
harro |
Updated [Time, Aircraft type, Nature, Source, Narrative] |
05-Mar-2010 10:38 |
harro |
Updated [[Time, Aircraft type, Nature, Source, Narrative]] |
18-Jul-2014 17:43 |
Dr. John Smith |
Updated [Time, Location, Departure airport, Destination airport, Source, Narrative] |
08-Sep-2014 19:48 |
Aerossurance |
Updated [Source, Narrative] |
21-Dec-2016 19:14 |
ASN Update Bot |
Updated [Time, Damage, Category, Investigating agency] |
21-Dec-2016 19:16 |
ASN Update Bot |
Updated [Time, Damage, Category, Investigating agency] |
21-Dec-2016 19:20 |
ASN Update Bot |
Updated [Time, Damage, Category, Investigating agency] |
03-Dec-2017 10:45 |
ASN Update Bot |
Updated [Operator, Other fatalities, Departure airport, Destination airport, Source, Narrative] |
The Aviation Safety Network is an exclusive service provided by:
CONNECT WITH US:
©2024 Flight Safety Foundation