ASN Wikibase Occurrence # 198789
This information is added by users of ASN. Neither ASN nor the Flight Safety Foundation are responsible for the completeness or correctness of this information.
If you feel this information is incomplete or incorrect, you can submit corrected information.
| Date: | Wednesday 8 March 2017 |
| Time: | 13:30 |
| Type: |  Grob G 109B |
| Owner/operator: | Private |
| Registration: | N109FH |
| MSN: | 6367 |
| Year of manufacture: | 1985 |
| Total airframe hrs: | 5677 hours |
| Engine model: | Grob 2500 |
| Fatalities: | Fatalities: 0 / Occupants: 1 |
| Aircraft damage: | Substantial |
| Category: | Accident |
| Location: | Mokuleia, Oahu, HI -
 United States of America
|
| Phase: | En route |
| Nature: | Private |
| Departure airport: | Oahu-Dillingham Airfield, HI (HDH/PHDH) |
| Oahu-Dillingham Airfield, HI (HDH/PHDH) | |
| Investigating agency: | NTSB |
| Confidence Rating: |  Accident investigation report completed and information captured |
The pilot, who was the owner of the powered glider, reported that, during the preflight, he “did not note any anomalies or irregular motion of the control surfaces.” He added that, during a turn in cruise flight, the rudder pedals “abruptly became unusual.” He looked to the rear of the powered glider and saw that the rudder had detached from the top of the vertical stabilizer. He added that the adverse yaw was “mild,” so he continued to land. During the landing roll, the rudder separated from the empennage.
Photographs provided by the Federal Aviation Administration showed extensive corrosion on the rudder hinges. The upper hinge showed a clean fracture surface on both the rudder and vertical stabilizer sides of the hinge.
The pilot reported that he has an outdoor tie-down space on the airport where he parks the powered glider. The airport is located in a marine environment, less than 1/2 mile from the Pacific Ocean.
The flight manual section titled, “Daily Inspections,” stated, in part,
Prior to flight operations the following visual exterior checks have to be performed…
5. Tail unit
Proper installation
Securely locked
Control connections locked
Freedom of movement
Damage
Pitot pressure tube (vertical fin) checked, cover remove
A review of maintenance records revealed that the most recent annual inspection was completed about 14 months before the accident. The most recent inspection performed on the powered glider was a 6,000-hour “Extension of Life Time” inspection, which was performed about 9 months before the accident. In the 6,000-hour inspection checklist, all line items were initialed “satisfactory” except for the “visual check for any decay” line items for the aileron, controls in the fuselage, elevator/trim tab, and rudder, which were left uninitialed.
The mechanic who performed the most recent annual inspection and the 6,000-hour “Extension of Life Time” inspection reported that he did not notice anything abnormal during either inspection and that, during the 6,000-hour inspection, he did not carry his initials down to the “visual check for any decay” line items but that they were performed and that the condition looked “satisfactory.” He added that he believed the corrosion was responsible for the upper rudder hinge failure and that it is not uncommon for that amount of corrosion to form between the time of the most recent inspection and the accident flight. He recommended that the glider should have been inspected more often and rinsed with water daily to remove any salt residue from ocean spray.
In followup e-mail correspondence, the pilot reported that he believed that, during the “Extension of Life Time” inspection, all inspections had been renewed. He added that he learned after the accident that the annual inspection had not been performed.
Probable Cause: The failure of the upper rudder hinge during flight due to severe corrosion. Contributing to the accident were the pilot’s inadequate preflight inspection and the lack of an annual inspection.
Accident investigation:
 |
|
Sources:
NTSB
Location
Revision history:
| Date/time | Contributor | Updates |
|---|---|---|
| 19-Aug-2017 15:10 | ASN Update Bot | Added |
| 15-Jun-2023 04:00 | Ron Averes | Updated |
Corrections or additions? ... Edit this accident description
The Aviation Safety Network is an exclusive service provided by:
Quick Links:
| ASN Home | Send Correction / Feedback |
| FSF Home | Disclaimer | Copyright |
| Contact Us | Privacy Policy |
| Press / Media |
CONNECT WITH US:
©2024 Flight Safety Foundation