ASN Wikibase Occurrence # 370443
This information is added by users of ASN. Neither ASN nor the Flight Safety Foundation are responsible for the completeness or correctness of this information.
If you feel this information is incomplete or incorrect, you can submit corrected information.
| Date: | Wednesday 8 May 2002 |
| Time: | 17:00 LT |
| Type: |  Boeing 737-448 |
| Owner/operator: | Ryan International Airlines, lsf Aer Lingus |
| Registration: | EI-BXI |
| MSN: | 25052/2036 |
| Total airframe hrs: | 26400 hours |
| Engine model: | CFM International CFM563B-2 |
| Fatalities: | Fatalities: 0 / Occupants: 160 |
| Aircraft damage: | Minor |
| Category: | Serious incident |
| Location: | Miami, FL -
 United States of America
|
| Phase: | En route |
| Nature: | Passenger |
| Departure airport: | Montego Bay-Sangster International Airport (MBJ/MKJS) |
| Chicago-O'Hare International Airport, IL (ORD/KORD) | |
| Investigating agency: | NTSB |
| Confidence Rating: |  Accident investigation report completed and information captured |
The pilot stated that the aircraft had been performing normally during the flight to Jamaica, West Indies, except for with a slight vibration during the initial flight. During the return leg to Chicago, Illinois, the captain he said that the airplane started vibrating " ten times as bad", so he diverted to, and affected an otherwise uneventful landing, in Miami, Florida. He added that the vibration had continued throughout the flight, until "flaps five" was set during the approach, at which time the vibration stopped. After landing, examination of the airplane showed that about a 24-inch section of the right elevator trim tab had been missing from the aircraft. In addition to the examination of the elevator, the remaining parts adjacent to the separated tab to include two control rods with rod ends, one hinge fitting from the right hand elevator rear spar were removed and examined. The examination revealed the presence of fractures, wear marks to the control rod, as well as post fracture damage to the rods. In addition, the hinge fitting had also incurred fractures as well as severe post fracture rubbing to the lugs, and worn areas between the hinge lugs and the inboard and outboard surfaces of unfractured lugs. On the elevator, rubbing was noted in areas on the aft face and lower skin panels of the elevator rear spar. In addition, the rear spar reinforcing angle and elevator tab control rod inner fairing and external mast fitting had incurred also damage. Boeing reports documenting examinations of the remaining damaged portions of elevator and tab assembly have been included with this report. Pertinent maintenance records were not obtained from Ryan International Airlines or Aer Lingus PLC, and there was no evidence of compliance with Boeing's system maintenance program (SB 737-55A1070R1), pertinent to "freeplay" checks.
Probable Cause: Inadequate maintenance by company maintenance personnel and failure to comply with manufacturer recommended maintence procedures (SB 737-55A1070R1), which resulted in an inflight inseparation of a section of the airplane's right hand elevator control tab. A factor in the incident was the flight crew's continued operation of the airplane with a known deficiency.
Accident investigation:
 |
|
Sources:
NTSB MIA02IA094
Revision history:
| Date/time | Contributor | Updates |
|---|---|---|
| 25-Mar-2024 10:47 | ASN Update Bot | Added |
Corrections or additions? ... Edit this accident description
The Aviation Safety Network is an exclusive service provided by:
Quick Links:
| ASN Home | Send Correction / Feedback |
| FSF Home | Disclaimer | Copyright |
| Contact Us | Privacy Policy |
| Press / Media |
CONNECT WITH US:
©2024 Flight Safety Foundation